Brown Tape Making Machine

Brown Tape Making Machine

This Self Scotch Tape Making Machine is a combination of printing ,coating, drying and slitting, it can  make all kinds of sizes of clear tapes, printed tapes and color tapes.It is highly automatic, operates easily .

Brown Tape Making Machine

Introduction of four-axis winding new tape machine -- GL- X multi-function tape machine

Auxiliary accessories for the tape machine:

    6. Check whether there are any omissions in the installation, ensure the installation of the heater, the heat sensor, and the drive train; check whether the circuits are connected correctly, and the wires are not leaking; whether the whole body is offset incorrectly, and the oven has a gap.
    7. After the installation is correct, start the test machine one by one. If there is any abnormality, stop the machine immediately and check the adjustment; after confirming the completion, start the production again (pay attention to personal safety and machine safety during the operation). The tape machine constitutes an important part of its function:
Unwinding device - responsible for the discharge and winding of the parent roll, can be equipped with tension control.
Printed section - configurable for monochrome, two-color printing.
The sizing part consists of a topping roll and a squeegee roll for applying glue to the substrate. Oven part - dry the glue.
Slitting section - the substrate after the coating is cut as needed.
Winding part - Winding the tape after slitting, you can determine the length of the winding as needed, or you can collect large rolls.
    Transmission section - sub-chain drive and gearbox drive. The average speed of the chain drive is equal, but there is an instantaneous speed, which is not suitable for services with high precision. Slitting machine - slitting the tape machine
Pipe puller - unloading and loading the paper tube on the take-up reel by hydraulic pressure
Automatic pipe cutting machine - slitting the paper tube
Rewinding machine - finishing some of the tape defective products (especially the untidy winding) to reduce the defective rate.

Brown Tape Making Machine

Tape factory budget cost --

1. Product introduction
BOPP adhesive tape is made of biaxially oriented polypropylene film as base material and coated with acrylic pressure sensitive adhesive. It has adhesiveness, initial adhesion, good adhesion, convenient use and low cost, and various colors. Mainly use the general carton seal, lightweight wrapping and so on.
Color: transparent, milky white, beige, golden, earthy yellow and other colors.
Sealing tape specification
The thickness is 0.05mm, and the broadband has 36, 45, 48, 55, 60, 72mm, etc., which can be produced according to user requirements.
Sealing tape storage and use environment:
● The product should be packaged and stored in a cool dry environment to avoid exposure to sunlight, freezing and high temperatures. ● Store the environment at 20 °C ~ 30 °C to avoid places where the temperature is too high. ● The surface to be bonded should be clean, dry, free from grease or other contamination. ● The shelf life is half a year.

Product Features 
· Instant Adhesion - The sealing tape is sticky.
· Fixing ability - even with a small amount of pressure, it can be glued to the workpiece according to your ideas.
· Easy to tear - easy to tear off the tape without the tape stretching and dragging.
· Controlled deployment - The sealing tape pulls the tape in a controlled manner that is neither too loose nor too tight.
· Flexibility - The sealing tape can be easily adapted to sharp curves.薄 Thin – the sealing tape strip will not leave thick edge deposits.平滑 Smoothness - The sealing tape feels smooth and does not irritate the hands when pressed.
· Anti-transfer - no adhesive will be left after the sealing tape is removed. ? Anti-solvent – ??The backing material of the sealing tape prevents solvent penetration. ? Anti-fragmentation – the sealing tape does not have lobes.
· Anti-retraction - the sealing tape can stretch along the curved surface without retraction.
· Anti-stripping - the paint will be tightly fastened to the backing of the sealing tape.

About

Zhengzhou EAST IMPORT AND EXPORT co., ltd . ( a goulian group of company) a manufacturer and exporter for all kind of packaging machinery , like bopp tape coating machines, bopp tape slitting machines. Bopp tape core cutter, bopp tape core loader etc

Got any Questions?
CALL US NOW

+86-17744612788

gl006@guolianjixie.com